Trane Performance Air Handlers Manual de instalación Pagina 4
- Pagina / 132
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
4 CLCH-SVX07C-EN
Table of Contents
Warnings, Cautions and Notices
. . . . . . . . . . 2
Introduction
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Overview of Manual
. . . . . . . . . . . . . . . . . . . 6
Nameplate
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
General Information
. . . . . . . . . . . . . . . . . . . . . 7
Operating Environment
. . . . . . . . . . . . . . . . 7
Unit Description
. . . . . . . . . . . . . . . . . . . . . . . 7
Factory-Mounted Controls . . . . . . . . . . . . . 7
Pre-Packaged Solutions for Controls . . . . 7
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Pre-Installation Requirements
. . . . . . . . . . . . . 9
Receiving Checklist
. . . . . . . . . . . . . . . . . . . . 9
Assembly Hardware . . . . . . . . . . . . . . . . . . 9
Resolving Shipping Damage
. . . . . . . . . . . . 9
Storage Recommendations
. . . . . . . . . . . . 10
General Storage . . . . . . . . . . . . . . . . . . . . 10
Long-Term Storage . . . . . . . . . . . . . . . . . 10
Outdoor Storage Considerations . . . . . . 10
Preparing the Unit Site
. . . . . . . . . . . . . . . . 10
Roof Curb Installation Checklist
. . . . . . . . . 11
Unit Dimensions and Weights
. . . . . . . . . . . 12
Service Clearances
. . . . . . . . . . . . . . . . . . . . 12
Fans/Motors
. . . . . . . . . . . . . . . . . . . . . . . . . 20
Starter/VFD Weights . . . . . . . . . . . . . . . . . 20
Motor Weights . . . . . . . . . . . . . . . . . . . . . 20
Installation - Mechanical
. . . . . . . . . . . . . . . . 21
Lifting and Rigging
. . . . . . . . . . . . . . . . . . . 21
Remove Shipping Tie-Downs . . . . . . . . . 21
General Lifting Considerations . . . . . . . . 22
Lifting Hoods and Pipe Cabinets . . . . . . . 24
Forklifting Considerations . . . . . . . . . . . . 24
Unit Placement and Assembly
. . . . . . . . . . 25
Unit Placement . . . . . . . . . . . . . . . . . . . . . 25
Unit Assembly . . . . . . . . . . . . . . . . . . . . . 26
Ceiling Suspension . . . . . . . . . . . . . . . . . 26
Shipping Gussets . . . . . . . . . . . . . . . . . . . 27
Section-to-Section Assembly . . . . . . . . . 27
Pipe Cabinet Installation
. . . . . . . . . . . . . . . 32
Outdoor Unit Weather Hoods
. . . . . . . . . . .34
Stacked Outdoor Units
. . . . . . . . . . . . . . . . .34
Assembly hardware . . . . . . . . . . . . . . . . . .34
Unit assembly . . . . . . . . . . . . . . . . . . . . . . .35
Vertical Seam Cap Installation . . . . . . . . .36
Flashing Installation . . . . . . . . . . . . . . . . . .37
Indoor Dual-Path SDU/Winterizer Assembly
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42
Horizontal SDU/Winterizer Air Handler
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . .42
Vertical SDU/Winterizer Air Handler
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . .43
External Raceway Assembly
. . . . . . . . . . . .44
Component Installation Requirements
. . . . .45
Diffuser Section
. . . . . . . . . . . . . . . . . . . . . . .45
Filter Section
. . . . . . . . . . . . . . . . . . . . . . . . . .45
Filter Installation . . . . . . . . . . . . . . . . . . . . .45
Filter Placement . . . . . . . . . . . . . . . . . . . . .46
Fan Section
. . . . . . . . . . . . . . . . . . . . . . . . . . .62
Fan Isolation . . . . . . . . . . . . . . . . . . . . . . . .62
Adjusting the Isolators . . . . . . . . . . . . . . . .62
Seismic Application Requirements
. . . . . . .63
Anchor Requirements . . . . . . . . . . . . . . . .63
Anchor Pattern . . . . . . . . . . . . . . . . . . . . . .63
Hurricane Application Requirements
. . . . .64
Miami/Dade County Hurricane-Certified Air
Handlers . . . . . . . . . . . . . . . . . . . . . . . . . . .64
Approved Method for Anchoring Unit . . .64
Hurricane Unit Anchorage . . . . . . . . . . . . .65
Gas Heat Installation . . . . . . . . . . . . . . . . .66
Pipe Cabinet Installation . . . . . . . . . . . . . .67
Pipe Cabinet Hurricane Anchorage . . . . .69
Damper Section
. . . . . . . . . . . . . . . . . . . . . . .69
Damper Torque Requirements . . . . . . . . .70
Opposed-Blade and Parallel-Blade Damper
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78
Multizone Modules
. . . . . . . . . . . . . . . . . . . .79
Duct Connections
. . . . . . . . . . . . . . . . . . . . . .79
Fan Discharge Connections . . . . . . . . . . . .79
Damper Connections . . . . . . . . . . . . . . . . .80
- Installation, Operation 1
- Important 2
- Environmental Concerns! 2
- CLCH-SVX07C-EN 3 3
- Table of Contents 4
- Introduction 6
- General Information 7
- Required! 8
- Pre-Installation Requirements 9
- Storage Recommendations 10
- Preparing the Unit Site 10
- Microbial Growth! 11
- Unit Dimensions and Weights 12
- Fans/Motors 20
- Installation - Mechanical 21
- Unit Placement and Assembly 25
- Unit Assembly 26
- Ceiling Suspension 26
- Risk of Unit Dropping! 26
- Hole diameter 27
- CLCH-SVX07C-EN 29 29
- Detail A 32
- Butyl tape 32
- Outdoor Unit Weather Hoods 34
- Stacked Outdoor Units 34
- Unit assembly 35
- Flashing Installation 37
- Detail C 39
- Flashing Installation Notes 40
- Install flashing and hood 41
- Assembly 42
- External Raceway Assembly 44
- Diffuser Section 45
- Filter Section 45
- Filter Placement 46
- CLCH-SVX07C-EN 47 47
- 48 CLCH-SVX07C-EN 48
- CLCH-SVX07C-EN 49 49
- 50 CLCH-SVX07C-EN 50
- CLCH-SVX07C-EN 51 51
- 52 CLCH-SVX07C-EN 52
- CLCH-SVX07C-EN 53 53
- 54 CLCH-SVX07C-EN 54
- CLCH-SVX07C-EN 55 55
- 56 CLCH-SVX07C-EN 56
- Fan Section 62
- Seismic Application 63
- Requirements 63
- Hurricane Application 64
- Hurricane Unit Anchorage 65
- Gas Heat Installation 66
- Pipe Cabinet Installation 67
- 68 CLCH-SVX07C-EN 68
- Damper Section 69
- Damper Torque Requirements 70
- CLCH-SVX07C-EN 71 71
- 72 CLCH-SVX07C-EN 72
- CLCH-SVX07C-EN 73 73
- 74 CLCH-SVX07C-EN 74
- CLCH-SVX07C-EN 75 75
- 76 CLCH-SVX07C-EN 76
- CLCH-SVX07C-EN 77 77
- 78 CLCH-SVX07C-EN 78
- Multizone Modules 79
- Duct Connections 79
- Damper Connections 80
- CLCH-SVX07C-EN 81 81
- Discharge Plenum Connections 82
- Traq Damper Connections 83
- 84 CLCH-SVX07C-EN 84
- Other Connections 85
- Coil Piping and Connections 86
- Steam Coil Piping 87
- Breaker Cracking Pressure! 88
- Coil Condensate! 88
- Water Coil Piping 89
- Liquid Lines 91
- Valve Damage! 91
- Suction Lines 92
- Installation - Electrical 100
- Quick Connects 101
- Controls Interface 104
- External communications port 105
- Start-Up 106
- Unit Operation 107
- Tension the Fan Belt 109
- NOTICE: 109
- Belt Tension! (2 of 2) 109
- Determine Fan Speed 110
- Live Electrical Components! 110
- Align Fan and Motor Sheaves 111
- Check Multiple Belts 111
- Traq™ Dampers 111
- Transmitter Sizing 117
- Transmitter Calibration 117
- Constant Factor K 118
- Maintenance 120
- Routine Maintenance 121
- Air Filters 122
- Drain Pans 122
- Inspecting and Cleaning Fans 123
- Bearing Set Screw Alignment 123
- Rotating Components! 123
- Coil Winterization 126
- Moisture Purge Cycle 126
- Coil Freeze-up! 126
- Ultraviolet (UV) Light 128
- Troubleshooting 129
© 2020, manymanuals.es. Todos los derechos reservados | 0.057 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales