Trane Performance Air Handlers Manual de instalación descargar pdf (Pagina 72)

100

72 CAH-SVX01B-EN

Installation - Electrical

Quick Connects

The actuators, factory-mounted or field-supplied, are separately wired and controlled by a direct-

digital controller or other building logic. Figure 71 illustrates the typical quick connect scheme.

Figure 70. Valve jack wiring details

Valve

quick

connect

Conduit

assembly

Figure 71. Typical quick connects with wiring identification

1 2 ... 67 68 69 70 71 72 73 74 75 76 77 ... 99 100

Custom Climate Changer™ 1
Air Handlers 1
WARNING 2
 WARNING 3
Table of Contents 4
CAH-SVX01B-EN 5 5
6 CAH-SVX01B-EN 6
CAH-SVX01B-EN 7 7
General Information 8
Pre-Installation Requirements 10
Resolving Shipping Damage 11
Storage Recommendations 11
Preparing the Unit Site 12
Roof Curb Structurally Sound 13
Suggested Tools 14
Installation - Mechanical 15
Lifting Considerations 16
Unit Assembly 17
TCP Standard Roof Curb 18
TCP Flat Concrete Pad 20
TCP Wall Section Assembly 25
TCP Stacked Unit Assembly 31
Remove shipping blocks 33
Butyl tape 34
Insert hardware in each hole 34
Rod threaded 35
62-11x13.38, THD 35
Lockwasher .625 35
Nut 62-11 35
Washer .563 ID x 1.375 OD 36
Bolt .500-13 x 3.500 Hex 36
Nut .500-13 Hex Mach 36
TCC Stacking Procedure 40
Pipe Cabinet Installation 43
Duct Connections 46
Isolator Adjustment 48
Side Load Filters 50
2-inch or 4-inch flat filters 50
Bag or Cartridge Filters 51
Outdoor Unit Weather Hood(s) 52
Coil Piping and Connections 53
Steam Coil Piping 56
Breaker Cracking Pressure! 57
Coil Condensate! 57
Water Coil Piping 58
Refrigerant Coil Piping 60
Valve Damage! 62
Suction Lines 62
Installation - Electrical 69
Penetration Leaks! 71
Quick Connects 72
Controls Interface 73
External Communications Port 74
Start-Up 75
Coil-Related Checks 76
Proper Water Treatment! 76
Motor-Related Checks 76
Voltage imbalance = 77
AvgVoltage× 77
Tension the Fan Belt 78
Belt Tension! 78
Determine Fan Speed 79
Align Fan and Motor Sheaves 80
Check Multiple Belts 80
Traq™ Dampers 81
Transmitter Sizing 82
Transmitter Calibration 83
Constant Factor K 83
Microbial Growth! 84
Routine Maintenance 85
Fan Bearing Lubrication 89
Bearing Failure! 89
Bearing Set Screw Alignment 89
Coil Winterization 93
 CAUTION 97
Troubleshooting 98

Comentarios a estos manuales

Sin comentarios

Trane Performance Air Handlers Manual de instalación Pagina 72

Comentarios a estos manuales

Relacionado con productos y manuales para Acondicionadores de aire del sistema de división Trane Performance Air Handlers